浏览全部资源
扫码关注微信
一起1000千伏GIL气室SO2超标问题分析
Analysis of the SO2 Exceedance in the 1000 kV GIL Gas Chamber
- 默认刊物名称 2025年
- 作者机构：
1.国网河南省电力公司电力科学研究院,河南省郑州市,中国
2.国网河南省电力公司,河南省郑州市,中国
- 作者简介：
- 基金信息：
DOI：
中图分类号：收稿日期：2024-12-31，
修回日期：2025-02-13，
录用日期：2025-02-14，
- 稿件说明：
移动端阅览
辛伟峰, 宋伟, 寇晓适, 等. 一起1000千伏GIL气室SO2超标问题分析[J/OL]. 默认刊物名称, 2025.
Analysis of the SO2 Exceedance in the 1000 kV GIL Gas Chamber[J/OL]. Moren journal, 2025.
摘要
GIL作为一种新型的高压输电技术，在高压输电及复杂电力传输环境中得到广泛应用，其可靠性直接关系电力系统的安全稳定运行。文中针对国内首台首套全户外1000千伏GIL设备的气室SO₂超标问题进行分析，通过对设备进行拆解检查、试验测试与仿真分析，确认事故原因为厂内装配工装观察面狭小，存在挡圈装配不到位风险，且垂直段壳体应力集中，致使挡圈脱出，触头虚接，进而导致局部放电和过热，使SF₆分解产生SO₂。最后基于故障原因分析，提出针对性的改进措施，为该型GIL的运维和故障防范提供实践经验与指导意见。
Abstract
Gas Insulated Line (GIL)
as a novel high-voltage transmission technology
has been widely applied in high-voltage transmission and complex power transmission environments. Its reliability is crucial for the safe and stable operation of power systems. This paper presents a detailed analysis of the SO₂ overlimit issue observed in the gas chamber of the domestically first outdoor 1000 kV GIL. Through disassembly
inspection
experimental testing
and simulation analysis
it was confirmed that the cause of the accident was that the narrow observation space of the assembly tooling in the manufacturing process led to the risk of improper assembly of the retaining ring. Additionally
stress concentration in the vertical section of the shell caused the retaining ring to dislodge
resulting in poor contact between the contacts. This in turn led to partial discharge and overheating
which caused the decomposition of SF₆ and the generation of SO₂. Based on the analysis of the failure mechanism
targeted improvement measures are proposed
providing valuable practical experience and guidance for the operation
maintenance
and fault prevention of this type of GIL.
关键词
Keywords
references
李星 , 丁登伟 , 吴传奇 , 等 . 550kV GIL三支柱绝缘子表面金属异物局部放电发展规律和闪络特性研究 [J/OL ] . 中国电机工程学报 , 1 - 10 .
LI Xing , DING Dengwei , WU Chuanqi , et al . Research on the Partial Discharge Development and Flashover Characteristics of Metal Particle on a 550 kV GIL Triple Post Insulator Surface [J ] . Proceedings of the CSEE , 2024-12-19
ZHANG Lei ， WANG Ya ， YU Di ， et al . Conductor Surface Roughness-dependent Gas Conduction Process for HVDC GIL—Part I: Simulation [J ] . IEEE transactions on Dielectrics and Electrical Insulation ， 2021 , 28 ( 2 ): 511 ⁃ 519 .
彭宗仁 , 张鹏飞 , 刘鹏 , 等 . 苏通综合管廊工程特高压GIL绝缘关键技术 [J ] . 高电压技术 , 2023 , 49 ( 10 ): 4046 - 4057 .
PENG Zongren , ZHANG Pengfei , LIU Peng , et al . Key Insulation Technology of UHV GIL in Sutong Utility Tunnel Project [J ] . High Voltage Engineering , 2023 , 49 ( 10 ): 4046 - 4057 .
黎斌 , 刘琳 , 梁作栋 , 等 . 特高压直流GIL绝缘设计与研究 [J ] . 高压电器 , 2024 , 60 ( 02 ): 1 - 25 .
LI Bin , LIU Lin , LIANG Zuodong , et al . Insulation Structure Design and Research of UHV DC GIL [J ] . High Voltage Apparatus , 2024 , 60 ( 02 ): 1 - 25 .
梁芳蔚 , 张长虹 , 吕金壮 , 等 . 直流气体绝缘输电线路关键问题及装备研发现状综述 [J ] . 高压电器 , 2023 , 59 ( 09 ): 1 - 11 .
LIANG Fangwei , ZHANG Changhong , LYU Jinzhuang , et al . Review of Key Problems and Development Status of DC Gas Insulated Transmission Line [J ] . High Voltage Apparatus . 2023 , 59 ( 09 ): 1 - 11 .
班连庚 , 孙岗 , 项祖涛 , 等 . 特高压苏通综合管廊工程GIL系统工作条件 [J ] . 电网技术 , 2020 , 44 ( 06 ): 2386 - 2393 .
BAN Liangeng , SUN Gang , XIANG Zutao , et al . System Conditions of UHV GIL in Sutong Utility Tunnel Project [J ] . Power System Technology , 2020 , 44 ( 06 ): 2386 - 2393 .
XUE Jianyi , CHEN Junhong , DONG Junhao , et al . A novel sight for understanding surface charging phenomena on downsized HVDC GIL spacers with non-uniform conductivity [J ] . International journal of electrical power & energy systems , 2020 , 120 : 105979 .
黎斌 , 刘琳 , 梁作栋 , 等 . 特高压直流GIL运行可靠性设计与研究 [J ] . 高压电器 , 2024 , 60 ( 03 ): 69 - 79 .
LI Bin , LIU Lin , LIANG Zuodong , et al . Design and Research on Operation Reliability of UHV DC GIL [J ] . High Voltage Apparatus , 2024 , 60 ( 03 ): 69 - 79 .
刘溟 , 邹建明 , 李振柱 , 等 . GIL内SO 2 F 2 扩散特性及其对组分检测的影响 [J ] . 高压电器 , 2021 , 57 ( 11 ): 27 - 34 .
LIU Ming ， ZOU Jianming ， LI Zhenzhu ， Diffusion Characteristics of SO 2 F 2 in GIL and Its Influence on Component Detection [J ] . High Voltage Apparatus , 2021, 57 ( 11 ): 27 - 34 .
王辉 , 李晓军 , 李舟 , 等 . SF 6 电气设备绝缘故障诊断用SO 2 、H 2 S气体传感器研究进展 [J ] . 高压电器 , 2019 , 55 ( 8 ): 1 ⁃ 9 .
WANG Hui , LI Xiaojun , LI Zhou , et al . Research progress of SO 2 and H 2 S gas sensors for insulation fault detection of SF 6 electrical equipment [J ] . High Voltage Apparatus , 2019 , 55 ( 8 ): 1 ⁃ 9 .
吴德贯 , 彭翔 , 李红元 , 等 . 一起500kVGIL绝缘子炸 裂故障分析 [J ] . 电瓷避雷器 , 2016 ( 1 ): 40 ⁃ 43 ．
WU Deguan , PENG Xiang , LI Hongyuan , et al . Analysis of a 500 kV GIL insulator burst fault [J ] . Insulators and Surge Arresters , 2016 ( 1 ): 40 ⁃ 43 .
贺毅 , 张靖 , 张英 , 等 . 基于流体力学的SF 6 电气设备中SO 2 和H 2 S气体扩散特性计算 [J ] . 电力大数据 , 2021 , 24 ( 08 ): 50 - 58 .
HE Yi , ZHANG Jing , ZHANG Ying , et al . Calculation of SO 2 and H 2 S gas diffusion characteristics in SF 6 electrical equipment based on fluid mechanics study [J ] . Power System and Big Data , 2021 , 24 ( 08 ): 50 - 58 .
翟晓卉 , 史会轩 , 刘晓波 , 等 . 基于光学方法的SF 6 绝缘电气设备分解产物检测技术研究现状与发展 [J ] . 工业安全与环保 , 2018 , 44 ( 01 ): 61 - 64 ．
ZHAI Xiaohui , SHI Huixuan , LIU Xiaobo , et al . Review of SF6 decomposition detecting methodology for SF 6 electrical devices based on optical technology [J ] . Industrial Safety and Environmental Protection , 2018 , 44 ( 01 ): 61 - 64 ．
蒋庆明 , 张艳妹 , 王明祥 , 等 . SF 6 分解组分的气体传感器检测方法综述 [J ] . 绝缘材料 , 2024 , 57 ( 03 ): 1 - 14 .
JIANG Qingming , ZHANG Yanmei , WANG Mingxiang , et. al . Review of gas sensor detection methods for SF 6 decomposition components [J ] . Insulating Materials , 2024 , 57 ( 03 ): 1 - 14 .
0
浏览量
0
下载量
0
CSCD
- 网络PDF下载
- WORD下载
- Meta-XML下载
- BibTeX下载
- Endnote下载
- RefMan 下载
- NoteExpress下载
- NoteFirst下载
关联资源
相关文章
相关作者
相关机构
- 技术支持由北京北大方正电子有限公司提供 陕ICP备05005324号-4
陕公网安备 61010402000197 - 本系统建议在Chrome、 IE9+ 以上版本浏览器阅读本站内容，360浏览器请切换至极速模式
- Cookies帮助我们提供服务并提供个性化体验。使用本网站，即表示您同意我们使用Cookies