油浸式正立式电流互感器产气故障的诊断及仿真分析

王英杰; 陈波; 白洁; 赵顺; 刘学芳; 车传强

doi:null

您当前的位置：

首页 >

文章列表页 >

油浸式正立式电流互感器产气故障的诊断及仿真分析

高电压与放电等离子体专题 | 更新时间：2026-07-06

- 油浸式正立式电流互感器产气故障的诊断及仿真分析
- Diagnosis and Simulation Analysis of Gas Generation Faults in Conventional Upright Oil-Immersed Current Transformers
- 高压电器 2026年
- 作者机构：
  
  1.内蒙古电力集团有限责任公司内蒙古电力科学研究院分公司，呼和浩特 010020
  2.内蒙古自治区电力系统智能化电网仿真企业重点实验室，呼和浩特 010020
  3.Inner Mongolia Power Dispatching Control Center, Hohhot 010010, China
- 作者简介：
  
  王英杰（1997），男，包头人，毕业于湖南大学电气工程及其自动化专业，工程师，从事电气一次设备故障分析及高试设备检测相关工作。E-mail：mbswcw@163.com
  陈波（1984），男，包头人毕业于华北电力大学电气工程及其自动化从事输变电技术监督及试验室检测工作，chenbo0472@163.com
- 基金信息：
  
  2024年电科院青年科技人员支持计划项目“蒙西地区充油变压器运行状态智能监测及预警技术研究”(2024-QK-02)
- DOI：
  中图分类号：
- 收稿：2025-06-10，
  
  修回：2025-11-13，
  
  录用：2025-11-17，
- 稿件说明：
移动端阅览
王英杰, 陈波, 白洁, 等. 油浸式正立式电流互感器产气故障的诊断及仿真分析[J/OL]. 高压电器, 2026.

WANG Yingjie, CHEN Bo, BAI Jie, et al. Diagnosis and Simulation Analysis of Gas Generation Faults in Conventional Upright Oil-Immersed Current Transformers[J/OL]. High VoltageApparatus, 2026.
王英杰, 陈波, 白洁, 等. 油浸式正立式电流互感器产气故障的诊断及仿真分析[J/OL]. 高压电器, 2026. DOI：

WANG Yingjie, CHEN Bo, BAI Jie, et al. Diagnosis and Simulation Analysis of Gas Generation Faults in Conventional Upright Oil-Immersed Current Transformers[J/OL]. High VoltageApparatus, 2026. DOI：

摘要

为研究油浸正立式电流互感器“产气—电容屏微放电”的联系，结合某地区共3台同型号220kV电流互感器发生波纹膨胀器顶盖故障，对其中2台互感器开展了故障分析工作。对故障电流互感器开展绝缘电阻、介损值电容量测试及油气分析试验，发现故障互感器油中H

、总烃及C

均超过注意值，绝缘油介损值超过注意值。随后对故障电流互感器开展解体检查，发现其一次绕组外部的绝缘纸及各层电容屏存在大量褶皱，工艺缺陷明显。基于COMSOL Multiphysics 6.3，建立一次绕组外部及油纸绝缘、褶皱气隙有限元模型，仿真分析其工艺缺陷状况下的放电过程，结合解体和试验结果，明确了故障原因。

Abstract

To investigate the correlation between gas generation and capacitive screen micro-discharge in oil-immersed upright current transformers

failure analysis was performed on two out of three 220kV current transformers (same model) that experienced bellows expansion tank cover failures in a regional power grid. The faulty units

underwent insulation resistance measurement

dielectric loss tangent (tanδ) and capacitance testing

and dissolved gas analysis (DGA). Results revealed that hydrogen (H

)

total hydrocarbon content

and ethylene (C

) concentrations in the insulating oil exceeded warning thresholds

accompanied by elevated dielectric loss values. Post-disassembly inspections identified significant wrinkling in the insulation paper surrounding the primary winding and across capacitive screen layers

indicating critical manufacturing defects. Using COMSOL Multiphysics 6.3

finite element models were developed to simulate the primary winding’s external insulation structure

oil-paper interfaces

and wrinkled air gaps. Partial discharge processes under these defect conditions were analyzed

confirming that insulation irregularities and capacitive screen deformation induced localized electric field concentrations. Combined with experimental and dissection findings

the root cause was attributed to progressive micro-discharges at wrinkled regions

exacerbated by degraded oil insulation properties

ultimately leading to gas accumulation and structural failure.

关键词

Keywords

references

郑立群 . 高电压油浸电流互感器局部放电原因分析及其制造中需要注意的问题 [J ] . 变压器 , 2016 , 53 ( 03 ): 35 - 38 .

ZHENG Liqun ; " Cause analysis of partial discharge in high-voltage oil-immersed current transformers and key issues in manufacturing ," Transformer , vol. 53 , no. 3 , pp. 35 – 38 , 2016 .

何清 , 王伟 , 陈元 , 等 . 一起220 kV油浸式电流互感器故障分析 [J ] . 电力电容器与无功补偿 , 2018 , 39 ( 03 ): 111 - 115 .

HE Qing , WANG Wei , CHEN Yuan et al ., " Failure analysis of a 220 kV oil-immersed current transformer ," Power Capacitor & Reactive Power Compensation, vol. 39 , no. 3 , pp. 111 – 115 , 2018.

王伟 , 郑含博 , 韩金华 , 等 . 一起500kV电流互感器闪络故障原因分析 [J ] . 变压器 , 2016 , 53 ( 09 ): 64 - 67 .

Wang Wei , ZHENG Hanbo , HAN Jinhua et al ., " Cause analysis of flashover failure in a 500 kV current transformer ," Transformer, vol. 53 , no. 9 , pp. 64 – 67 , 2016.

马奎 , 吴旭涛 , 马炜 , 等 . 油浸倒置式CT双针缺陷模型设计及其局放特性研究 [J ] . 绝缘材料 , 2015 , 48 ( 08 ): 56 - 60+66 .

MA Kui , WU Xutao , MA Wei et al . , " Design of double-needle defect model and partial discharge characteristics

of inverted oil-immersed current transformers , " Insulating Materials , vol . 48 , no . 8 , pp. 56 – 60+66 , 2015 .

International Electrotechnical Commission . IEC 60599:2022 , Guide for the interpretation of dissolved and free gases in mineral insulating oils in electrical equipment [S ] . Geneva : IEC , 2022 .

国家能源局 . DL/T 722—2014 , 变压器油中溶解气体分析和判断导则 [S ] . 北京：中国电力出版社， 2014 .

DL/T 722 -2014, " Guide for Analysis and Judgment of Dissolved Gases in Transformer Oil" , National Energy Administration , 2014 .

王琼 , 杨文良 , 车传强 , 等 . 一起油浸式电流互感器局部放电缺陷的诊断和分析 [J ] . 变压器 , 2020 , 57 ( 03 ): 82 - 86 .

WANG Qiong , YANG Wenliang , CHE Chuanqiang et al ., " Diagnosis and analysis of partial discharge defects in an oil-immersed current transformer ," Transformer , vol. 57 , no. 3 , pp. 82 – 86 , 2020 .

连鸿松 . 油中气体含量对电容型设备绝缘性能的影响研究 [J ] . 电力电容器与无功补偿 , 2017 , 38 ( 05 ): 96 - 101 .

LIAN Hongsong , " Impact of gas content in oil on insulation performance of capacitive equipment ," Power Capacitor & Reactive Power Compensation , vol. 38 , no. 5 , pp. 96 – 101 , 2017 .

高树功 , 胡则剑 , 刘红文 , 等 . 35 kV配电线路铁磁谐振诱发电压互感器油色谱异常的研究 [J ] . 绝缘材料 , 2019 , 52 ( 02 ): 81 - 86 .

GAO Shugong , HU Zejian , ZHENG Hongwen et al ., " Study on oil chromatography abnormalities of voltage transformers caused by ferroresonance in 35 kV distribution lines ," Insulating Materials, vol. 52 , no. 2 , pp. 81 – 86 , 2019.

于会民 , 王会娟 , 杨雪 , 等 . 高压互感器用绝缘油的性能对比分析 [J ] . 绝缘材料 , 2023 , 56 ( 09 ): 101 - 107 .

YU Huimin , WANG Huijuan , YANG Xue et al ., " Comparative analysis of insulating oil properties for high-voltage transformers ," Insulating Materials , vol. 56 , no. 9 , pp. 101 – 107 , 2023 .

燕宝峰 , 郭红兵 , 韩磊 , 等 . 一起油浸式电流互感器缺陷原因分析 [J ] . 内蒙古电力技术 , 2013 , 31 ( 05 ): 120 - 122 .

YAN Baofeng , GUO Hongbin , HAN Lei et al ., " Cause analysis of defects in an oil-immersed current transformer ," Inner Mongolia Electric Power Technology , vol. 31 , no. 5 , pp. 120 – 122 , 2013 .

杨家辉 , 程建伟 , 张曦 , 等 . 500 kV SF6电流互感器主绝缘故障的仿真分析 [J ] . 南方电网技术 , 2017 , 11 ( 05 ): 29 - 35 .J.

YANG Jiahui , CHENG Jianwei , ZHANG Xi et al ., " Simulation analysis of main insulation failure in 500 kV SF 6 current transformers," Southern Power System Technology , vol. 11 , no. 5 , pp. 29 – 35 , 2017.

王成智 , 胡伟 , 罗晓庆 , 等 . 电热联合作用下交流油浸纸套管绝缘特性 [J ] . 高电压技术 , 2019 , 45 ( 08 ): 2629 - 2636 .

WANG Chengzhi , HU Wei , LUO Xiaoqing et al ., " Insulation characteristics of AC oil-impregnated paper bushings under combined electrical-thermal stress ," High Voltage Engineering , vol. 45 , no. 8 , pp. 2629 – 2636 , 2019 .

张金烽 . 复合电场下油纸绝缘低温介电与击穿特性研究 [D ] . 哈尔滨理工大学 , 2019 .

ZHANG Jinfeng "Dielectric and breakdown characteristics of oil-paper insulation under combined electric fields at low temperatures , " (Ph.D. Dissertation) , Harbin University of Science and Technology , 2019 .

罗毅 , 方志 , 邱毓昌 , 等 . 介质阻挡放电影响因素分析 [J ] . 高压电器 , 2004 ,( 02 ): 81 - 83 .

LUO Yi , FANG Zhi , QIU Yuchang et al ., " Analysis of influencing factors on dielectric barrier discharge ," High Voltage Apparatus , vol. 40 , no. 2 , pp. 81 – 83 , 2004 .

杨智 , 郑一鸣 , 何文林 , 等 . 一起油浸倒置式电流互感器故障分析及其防范措施 [J ] . 电力电容器与无功补偿 , 2020 , 41 ( 03 ): 99 - 105 .

YANG Zhi , ZHENG Yiming , HE Wenlin et al ., " Fault analysis and preventive measures for an inverted oil-immersed current transformer ," Power Capacitor & Reactive Power Compensation , vol. 41 , no. 3 , pp. 99 – 105 , 2020 .

王有元 , 李伯男 , 黄磊峰 , 等 . 倒置式油浸电流互感器受潮过程微水含量动态推演方法 [J ] . 高电压技术 , 2021 , 47 ( 06 ): 1921 - 1930 .

WANG Youyuan , LI Bonan , HUANG Leifeng et al ., " Dynamic deduction method for moisture content during dampness process of inverted oil-immersed current transformers ," High Voltage Engineering , vol. 47 , no. 6 , pp. 1921 – 1930 , 2021 .

Q/ND 10501 06—2023《输变电设备状态检修试验规程》 . Q/ND 10501 - 06 —2023,"Condition-based Maintenance Test Regulations for Power Transmission and Transformation Equipment", 2023 .

李文燕 , 刘江明 , 张翾喆 , 等 . 电流互感器末屏断裂缺陷及其影响分析 [J ] . 电力电容器与无功补偿 , 2020 , 41 ( 05 ): 95 - 98+103 .

LI Wenyan , LIU Jiangming ， ZHANG Xuanzhe , et al ., "Analysis of fractured screen defects in current transformers and their impacts," Power Capacitor & Reactive Power Compensation , vol. 41 , no . 5 , pp. 95 – 98+103 , 2020 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

均压环断裂倾斜对复合绝缘子电场影响的研究

隔离开关和盆式绝缘子故障下的GIS外壳振动特性仿真研究

500 kV避雷器上节泄漏电流测试研究

伞裙破损对接触网斜腕臂绝缘子电场特性的影响

基于磁导—电容类比法的高频变压器电磁建模及参数提取方法